Product ID:ACID WASH PRIMER PHOSPRO, X-5679
MSDS Date:10/01/1991
FSC:8010
NIIN:00N092065
Status Code:A
MSDS Number: CJMJL

FARWEST PAINT MANUFACTURING CO

4522 SOUTH 133RD ST
TUKWILA, WA 98168
US

Emergency Phone: 800-424-9300

Info Phone: 206-244-8844

Cage: 6F266

FARWEST PAINT MANUFACTURING CO

TUKWILA, WA 98168 US

Telephone: 206-244-8844

Cage: 6F266

PHOSPHORIC ACID

CAS: 7664-38-2

RTECS: TB6300000

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ZINC CHROMATE

CAS: 13530-65-9

RTECS: GB3290000

OSHA PEL 0.01 MG/M3

ACGIH TLV: 0.01 MG/M3

ISOPROPANOL

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 980 MG/M3;400 PPM

ACGIH TLV: 983 MG/M3;400 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: INHALATION OF MIST
CAN CAUSE DAMAGE TO NASAL AND RESPIRATORY PASSAGES. SKIN/EYE
CONTACT: CAUSES BURNS. INGESTION: RESULTS IN SEVERE DAMAGE MUCOUS
MEMBRANES.
Explanation of Carcinogenicity:ZINC CHROMATE: IARC MONOGRAPHS
SUPPLEMENT ON EVALUATION OF CARCINOGENIC RISK OF CHEMICALS TO MAN,
VOL 49, PG 49, 1990: GROUP 1. NTP 8TH ANNUAL REPORT ON CARCINOGENS,
1998: KNOWN TO BE CARCINOGENIC. AN IMAL: LUNGS.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE, WHEN USED I/A/W SAFE HANDLING
INSTRUCTIONS (SEE SAFE HANDLING AND USE INFORMATION SECTION).

First Aid:INHALATOIN: REMOVE TO FRESH AIR. IF RESPIRATORY SYMPTOMS
DEVELOP, SEEK MEDICAL ATTENTION AT ONCE. SKIN: WASH OFF QUICKLY
WITH PLENTY OF WATER, THEN SOAP AND WATER. GET MEDICAL ATTENTION.
REMOVE AND WA SH CONTAMINATED CLOTHING BEFORE REUSE. EYES: FLUSH
IMMEDIATELY WITH LARGE AMOUNTS OF WATER, ESPECIALLY UNDER LIDS, FOR
AT LEAST 30 MINUTES. OBTAIN EMERGENCY MEDICAL TREATMENT. INGESTION:
IF SWALLOWED, OBTAIN MEDICAL TREATMENT IMMEDIATELY. DO NOT INDUCE
VOMITING. GIVE LOTS OF WATER.

Flash Point:=26.7C, 80.F
Lower Limits:2%
Extinguishing Media:FOAM, DRY CHEMICAL, WATER OR WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS. PHOSPHORIC ACID IN CONTACT WITH MOST METALS MAY
GENERATE HYDROGEN GAS.
Unusual Fire/Explosion Hazard:WILL NOT BURN; CLOSED CONTAINERS MAY
BURST IF EXPOSED TO EXTREME HEAT OR FIRE. HAZARD RATING: HEALTH -
2; FLAMMABILITY - 0; REACTIVITY - 0.

Spill Release Procedures:COMPLY WITH ALL APPLICABLE HEALTH AND
ENVIRONMENTAL REGULATIONS. VENTILATE AREA. SPILLS MAY BE COLLECTED
WITH ABSORBENT MATERIALS.

Handling and Storage Precautions:USE ONLY WITH ADEQUATE VENTILATION.
AVOID BREATHING VAPOR AND SPRAY MIST. AVOID CONTACT WITH SKIN AND
EYES. KEEP FROM FREEZING. STORE CONTAINERS WITH LIDS TIGHTLY CLOSED
AND APPROPRIATELY LABELED.
Other Precautions:KEEP WORK AREA CLEAN AND FREE FROM SPILLS AND LEAKS.

Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED NIOSH
APPROVED ORGANIC VAPOR/PARTICULATE RESPIRATOR FOR PROTECTION
AGAINST INGREDIENTS.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
EXPOSURE TO INGREDIENTS IS MAINTAINED BELOW APPLICABLE EXPOSURE
LIMITS.
Protective Gloves:IMPERVIOUS GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES & FULL LENGTH
FACESHIELD .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:ALWAYS WASH HANDS THOROUGHLY WITH SOAP AND
WATER BEFORE HANDLING FOOD, DRINK OR SMOKING.
Supplemental Safety and Health
PHYSICAL DATA: VOC: 680 G/L (LESS WATER). WT/GAL: 8.05 LBS. REACTIVITY
IN WATER: NONE.

Boiling Pt:=65.6C, 150.F
Vapor Pres:30.0 MMHG @ 25C
Vapor Density:HVR/AIR
Spec Gravity:0.96
VOC Pounds/Gallon:680
pH:2.0
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INFINITE
Appearance and Odor:GREEN AQUEOUS ACIDIC LIQUID.
Percent Volatiles by Volume:50

Stability Indicator/Materials to Avoid:YES
ALKALINE AGENTS, COMBUSTIBLE MATERIALS, OXIDIZERS AND REDUCING AGENTS.
Stability Condition to Avoid:ELEVATED TEMPERATURES.
Hazardous Decomposition Products:MAY FORM TOXIC AND PHOSPHOROUS
COMPOUNDS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:DOT PROPER SHIPPING NAME: CORROSIVE LIQUID.
FLAMMABILITY CLASSIFICATION: OSHA: FLAMMABLE. DOT: FLAMMABLE,
CORROSIVE. HAZARD CLASS: CORROSIVE LIQUID. CLASS: 3.

SARA Title III Information:PURSUANT TO TITLE III OF THE SUPERFUND
AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA) AND 40 CFR PART
372, THIS PRODUCT CONTAINS OR MAY CONTAIN A TOXIC CHEMICAL IN A
QUANTITY SUBJECT TO THE REPORTI NG REQUIREMENTS UNDER SECTION 313.